Eastern Basin acid water plant is "sledgehammer"

Written by  Sheree Bega Thursday, 02 March 2017 10:53
Rate this item
(3 votes)

The Department of Water and Sanitation (DWS) has used a "sledgehammer" for its R1bn treatment plant for acid mine drainage (AMD) on the Eastern mining basin that could ultimately create more toxic water. 

This is the view of water strategy and consulting mining hydrologist Kym Morton, who believes government is "wasting money" by pumping large volumes of water and adding lime that makes it alkaline but still toxic and hazardous. 

"This is a sledgehammer approach to what can be solved by accurate monitoring and treatment of real AMD seepage at each decant point,"she says. 

Last week the DWS,  through the Trans-Caledon Tunnel Authority launched the treatment plant in Spring, the largest of its kind in the world, to counter the impact of 120 years of mining in the Witwatersrand basins. 

The plant is part of the short-term solution to halt the breaching of the environmental critical level in the Central and Eastern mining basins. 

Every day the TCTA pumps about 110million litres of water to mitigate against the pollution of underground water sources into the Blesbokspruit and the wetlands that then drain into the Vaal river system. 

But Morton says this draws down the level in the mine shaft to 120 m below the surface, exposing more pyrite to oxygen. 

This process could create more AMD, which us caused when oxygen and water come into contact with pyrites in exposed rock, sludge or tailings. 

"The pumping is therefore increasing the creation of AMD.....the DWS claims they've had a huge success in treating the water pumped from the shaft.

"The reality is they are not treating the water to a better state. All that is achieved is using expensive and scarce lime to increase the pH of the water from 3 to between 7,2 and 9.2.  The water leaving the pumping site is not drinkable, is hazardous to animals, humans, aquatic species and plants.  And because the pH has been altered, the metals in the water precipitate out as a sludge. 

"Unless the sledge is sealed from rain water, surface water runoff and ground water, the toxic elements will be mobilised and enter the water system."

"A better solution is to treat the water at source and remove both the metals and the sulphates for resale."

Philip de Jager, an attorney who represents communities in Springs agress. 

"What is of particular concern is that the sludge will be stored at the existing slimes dam situated next to the Blesbokspruit, and too close for comfort to the suburb of Strubenvale in Springs. 

"We're concerned about the possibility of flooding, which will have a negative impact on downstream property owners, including Marievale Bird Sanctuary."

 Professor Frank Winde of the mine research group at North West University says: "It's not only that the capital layout is significant; it is also the running costs for pumping the water from depth, adding the chemicals and disposing of the sludge, especially as it needs to be done indefinitely.  All of this with little to show as the discharged water is still largely unusable and the generates sludge may pollute other resources". 

His colleague, Ewald Erasmus, argues that if incentives were given to mining companies to remove uranium, the sulphates and as many other metal contaminants as economically possible, the "many will benefit, and not just a few". 

[An extract from the article'


Palmietkuilen Coal Mining Project Rejected

The Gauteng Department of Agriculture and Rural Development (GDARD) has refused to grant permission for the proposed Palmietkuilen Coal Mining Project.  The FSE with other interested and affected parties lodged an objection with the Department of Mineral Resources against the proposed open cast coal mine to be situated on the Palmietkuilen farm in Lesedi.

turn mine enviro hazards into jobs generator


It’s all about the money

The hazardous mining by-product raises two questions – who’s to blame and who sh...


FSE’s Preliminary Comments on the Minister of Water and Sanitation’s decision to consolidate the 9 Catchment Management Agencies into one Catchment Management Agency.

  (Reg. No. 2007/003002/08) NPO NUMBER 062986-NPO PBO No. (TAX EXEMPT) 930 039 506 Postnet Suite 87 Private Bag X033 RIVONIA 2128   COMMENTS ON THE DEPARTMENT OF WATER AND SANITATION’S DECISION TO IMPLEMENT A SINGLE CATCHMENT MANAGEMENT AGENCY (CMA) TO PERFORM WATER RESOURCE MANAGEMENT FUNCTION IN THE NINE WATER MANAGEMENT AREAS.  The following comments are submitted on behalf of the Federation for a Sustainable Environment. The Federation for a Sustainable Environment (FSE) is a federation of community based civil society organisations committed to the realisation of the constitutional right to an environment that is not harmful to health or well-being, and to having the environment sustainably managed and protected for future generations. The FSE’s mission is specifically focussed on addressing the adverse impacts of mining and industrial activities on the lives and livelihoods of vulnerable and disadvantaged communities who live and work near South Africa’s mines and industries.  


December 23 2017 POLLUTION OF VAAL RIVER ‘AT CRISIS POINT’ SHEREE BEGA “Extraordinary high levels of pollution” in the Vaal River are causing health risks, environmental degradation and water shortages.

The FSE on Al Jazeera English’s award-winning show, The Stream

The FSE will appear on Al Jazeera English’s award-winning show, The Stream Wednesday, December 20th from 9:30p – 10:00p SAST


Coalition defending Mpumalanga water source area

Last week, the coalition of eight civil society and community organisations that has been resisting the proposed coal mine inside a protected area and strategic water source area in Mpumalanga launched further proceedings in the Pretoria High Court.

Project to heal polluted river . System will·create stream·of jobs

THE POTENTIAL to create 100 climate jobs and to help : bring a "dead river syste...

'Mine Water can be treated, safe'

SOUTH Africans have to "change their mindsets" that they can't drink acid mine d...